Honda ATV Forum banner

rancher 420

  1. Honda Rancher
    I am getting no fuel spray at injector. I have spark, fuel pump just rebuilt operating properly and fuel in the line at the top of the injector. Have two oem injectors and both do the same. I have power at the connector at the injector. Engine will start on starting fluid just for a moment. Is...
  2. Honda Rancher
    I got my hands on a 420 with lots of mods but sounds like it might need a new top end. What's the best top end rebuild kit to go with? I'd like to get a good high compression kit that would be best suitable for mudding. Any suggestions or anyone done a rebuild that would like to give input?
  3. Repair & Maintenance
    Just recently bought a 2008 Honda Rancher 420 4x4 for my stepbrother for $1000. It supposedly has a fresh top end rebuild. It was running great up until the other night, not even 30 minutes into riding it, after we got to the mudpark. My stepbrother hit a hard bump, and it died. I noticed that...
  4. Honda Rancher
    I recently bought a 2007 Honda rancher 420 4x4 everything is good on it except for the front plastics and the front steering because of a wreck that they had gotten into. The welded the front right A-arm bracket onto the frame. I guess because they had bent it beyond repair. But with that being...
  5. Honda Rancher
    I have a 2018 Honda Rancher 420TRX 4X4 and cannot shift. It’sgiving a code 4. Starts and runs without a problem. I’ve tried looking for a conversion kit to just make it a manual shift and can not find one. I am at my wits end. Any help is greatly appreciated.
  6. Repair & Maintenance
    Model: 2009 Honda Rancher FA It will fire right up with starting fluid sprayed into the intake. It seems like it’s not getting fuel. I replaced the fuel petcock and drained/cleaned the fuel tank. The old petcock stem rotted out in the tank and I figured it clogged the fuel lines. Fuel pump...
  7. Repair & Maintenance
    Hi, I have a 2014 (07-13 bodystyle) Rancher 420 AT thats having some cranking problems. I’m the original owner and got it brand new. Super low hours/miles (150 hours, 280 Miles) so I wouldn’t think it’s anything major. When I turn they key on, the dash lights (the neutral light, temps true...
  8. Repair & Maintenance
    I have a 2010 rancher Fourtrax, efi eps es, all the electrical crap, parked it for a week, and went to start it, and it just cranks away with a blinking (-). I have replaced the Gear Position sensor, fuel pump relay, cleaned the es motor, cleaned most of the connectors, and re soldered all the...
  9. Repair & Maintenance
    The 420 goes into gear and engages. But when you give it throttle it starts to move but only makes the bike rock forward. I’ve checked the shift valve and all possible electrical issues. I haven’t tried changing the oil as it appeared to be new. My next move it to obviously change the oil. I...
  10. Repair & Maintenance
    So i recently bought an 07 rancher es. I got a good ride out of it one night, then took it out the following weekend, and about 2 hours in, i could not shift down at all. I could shift up, but not down. The previous owner replaced the shift motor, which still tried to shift even though its not...
  11. Repair & Maintenance
    All, I am sure there are one hundred posts regarding this but my 07 that I’ve had the best luck out of acted up on me today. I leave it in 1st gear when parked so it can’t be rolled away easily so when I start it, it’s typically in gear and I pull the right hand brake in to crank it. Long story...
  12. Repair & Maintenance
    Was wondering if somebody can point me in the right direction, recently was out on my rancher 420 and was drifting in 4wd and I tipped when I’ve tip the quad has gone into its side but all the weight was on the front right wheel. So it’s bent my wheel slightly nothing major , was wondering if...
  13. Repair & Maintenance
    Hello all, I'm new to the forum and hoping for some advice. Several weeks ago my 2007 rancher 420 manual shift atv wouldn't start, just the selenoid clicking. Then it started for a few weeks with no issue, then started the same thing. A no start issue and the selenoid just clicking I have...
  14. Honda Rancher
    Ok so I bought a 2016 from a guy for a good deal, top end is new but bottom end is knocking. Already took it apart and I'm mechanically inclined more on automotive side though. What I need to know is what do I need to look for as in bad parts. Crank? Bike started up fine and ran good also. No...
Top