Honda ATV Forum banner

Search results

1-20 of 48 Results
Advanced Search
  1. '06 TRX250TM slipping clutch?

    Honda FourTrax
    Is it reasonably easy to swap those components out without having to pull the motor? That's the big question.
  2. '06 TRX250TM slipping clutch?

    Honda FourTrax
    So just pull the front cover off and inspect? How big of a job is it to change that stuff out?
  3. '06 TRX250TM slipping clutch?

    Honda FourTrax
    I haven't been able to fully get all the power down on the quad. It's a semi-automatic, non-electric shift, TRX250. I can't find any information on this topic so I'm trying here. Whenever i'm in a high-ish gear and I give it some gas the engine RPMs go up but no power goes through the driveline...
  4. Short problem? Blown CDI

    Honda FourTrax
    big news my dudes. Thanks for the reply retro, I'm going to clean out all the fuel components later, but I got it to run pretty darn good. Fun fact, it ran so bad because it wasn't getting gas. Just had to let it suck the gas into the carb, and it ran fine. Runs a little rich, how would I lean...
  5. Short problem? Blown CDI

    Honda FourTrax
    oh and I didn't use force to put it on, I just had to tap it a little for it to set correctly. shifter works fine.
  6. Short problem? Blown CDI

    Honda FourTrax
    All the electrics work, even the nuetral switch and everything else the bolt that snapped was the bolt right above where the neutral switch comes out of the case. I filled it with Honda bond to prevent leaking and in the future I'll drill it out and replace it, but it doesn't seem to bad as of...
  7. Short problem? Blown CDI

    Honda FourTrax
    Big update. After having to cancel orders from rockymountain (because they were being stupid and sh**ty and making me wait over a month for one part), and having to wait weeks from partzilla I finally got my stator and regulator. I put it all together and screwed up the first time by putting the...
  8. Short problem? Blown CDI

    Honda FourTrax
    Could the kit be found somewhere else? I'm ordering off of the part picker diagram.
  9. Short problem? Blown CDI

    Honda FourTrax
    Thanks for the help! I'm getting the positive brush kit, but I cannot order the insulator! It's not anywhere to be found, and there is no number on the ordering diagram on rockymountain. There is a little bit of it left in the starter but i'm not sure if that's enough to properly insulate. I...
  10. Short problem? Blown CDI

    Honda FourTrax
    Update: figured out what that weird piece was. Seems to be a support thing for the positive connector nut. It probably broke when I was trying to get it off. I had a hard time with it.
  11. Short problem? Blown CDI

    Honda FourTrax
    You make a good point. I noticed this discoloration on the pulse coil. It's only on the top surface, not the sides of the pole. Does this mean it's a bad coil, or going bad? Also, I found lots of graphite powder and some weird brittle metal piece inside the starter, and it doesn't show up in the...
  12. Short problem? Blown CDI

    Honda FourTrax
    I looked at the stator more up close and personal and tested all the connections on it. I tested to see if there was continuity between one end of the exciter winding, and the other, right where the copper wire is soldered onto its leg. It was open. Which means that there is an open circuit in...
  13. Short problem? Blown CDI

    Honda FourTrax
    oh, forgot to mention, i'm ordering parts tonight and I'm wondering if I need to throw a new reg/rec in there just to be safe so it doesn't blow things up again
  14. Short problem? Blown CDI

    Honda FourTrax
    You people are Gods of small engines. I just learned a whole lot. So to summarize, because I have a brand new battery (it's an AGM btw), i shouldn't be worried about something happening again to the stator? And the headlights... what about them? Did they blow from a bad reg/rec? or was it...
  15. Short problem? Blown CDI

    Honda FourTrax
    I forgot to mention, my headlights were blown out when I first got it, so I'm thinking that the reg/rec blew them out because the quad also had a not so great battery on it....
  16. Short problem? Blown CDI

    Honda FourTrax
    why does running with a bad battery/no battery kill the stators? and how would i check the reg/rec to see if it's the cause?
  17. Short problem? Blown CDI

    Honda FourTrax
    Alright. It's apart. took a few days because of a few bottle necks in time from stuck bolts. One on the starter power terminal and the motor mounts. Anyways, I have a few questions before I order parts. For anyone who has done this before, what are things I should replace while I have the motor...
  18. Short problem? Blown CDI

    Honda FourTrax
    Thanks for the help! I'm going to order it from Rocky Mountain. What should I do to prevent the new stator from frying like this one did? Should I get a pulse coil just in case? And should I get a new gasket for the stator case? And one final question, how hard is it to pull the motor? Thanks guys.
  19. Short problem? Blown CDI

    Honda FourTrax
    Thanks for the reply! I do plan on having this awhile and want to put the best parts I can in it. I have a few questions though. For one, should I get a new pulse coil too? Just in case? the cheapest OEM stator and pulse coil I could find are here. But I am not sure if this is a very...
  20. Short problem? Blown CDI

    Honda FourTrax
    About 9 months later, and I've got an update! First I want to give a massive thanks to everyone who helped me out so long ago, all the information I got, and all the stuff I learned has helped me out ALOT. So thanks everyone. Alright, I've been busy with life, and mainly winter so I haven't had...
1-20 of 48 Results
Top